TOM THUMB REPAIR                                                PART 6

As 2017 progressed, the Tom Thumb Player Piano lost it's enthusiasm and by the time we closed for the season, it was ready for some help.

You will remember when we took the pumps out to check them, we found a piece of a piano action in the bottom of the case.    Well it is time to fix that.   In order to do so, the piano action has to be removed and in order to get to it, the player piano roll drive section has to come out.;

With the roll drive out, the piano action can be removed for the needed repair.   The rest of the key striking mechanism is removed and the unglued part can be glued back in place.

Then the parts are reassembled and a few other checks are made and the piano action is reinstalled in the piano.

                                                      TOM THUMB REPAIR                    PART 5

As 2017 progressed, the Tom Thumb Player Piano lost it's enthusiasm and by the time we closed for the season, it was ready for some help.

Well, we have all the pump sections checked and repaired as necessary.

The gaskets are glued where the joints come, replacing the silicon sealer used in the last repair.   This is a more conventional method, but will probably not seal any better.   It will however make the job easier for the next person

After the dry fit and repair of a few stripped screws, the pump is reassembled and ready for putting on the auxiliary control parts.

                                                             BUILDING EXCITEMENT


The building was erected in 1906 and there have been many changes and additions since then.  Never a day goes by without some echoes from our past.   On April 3, we had a new issue.   The sink on the second floor blew a water line and flooded the area.

From there, the water ran down to the mezzanine and over the telephone Centrix system control box.

From there the water came through the light fixture on the first floor and from there we were able to catch most of the water in pans.

The leak was caught quickly, but it was large, so we got a lot of water in a short time.   Of course, besides drying out the wet areas, we lost our phone service from water in the Centrix  box.   After uncovering the pc board and drying it out, the phone came back in about 1 hour.

Never a dull day at DeBence!

                                         TOM THUMB REPAIR                    PART 4


As 2017 progressed, the Tom Thumb Player Piano lost it's enthusiasm and by the time we closed for the season, it was ready for some help.

Well, removing the pump section damaged the bottom board because of the way it was firmly glued to the frame, so we made a new part and prepared to recover the section.

After duplicating the original hinge section, we have the section ready to recover.

Our intent is to use a more conventional gasket and screw the attachment to the frame.  So that the next person will not have the issues we faced, the gasket will be glued to the bottom of the pump section.